01 / OFFICIAL CAMPAIGNS
2025 Peterbilt 567 recall campaigns
NHTSA 24V433000
- Component
- STEERING
- Report received
- June 12, 2024
- Potential units
- 7,410campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth K270, K370, L770, T280, T380, T480, T680, T880, W900, W990, 2025 Peterbilt 220, 520, 536, 537, 548, 567, 579, and 589 trucks. The tie rod or drag link assembly may contain an improperly heat-treated ball stud, causing the ball stud to break.
Why it matters: A broken ball stud can cause a complete loss of steering control, increasing the risk of a crash.
Remedy
Owners are advised not to drive their vehicles until the remedy has been completed. Dealers will inspect and replace the tie rod and drag link assemblies as necessary, free of charge. Owner notification letters were mailed August 6, 2024. Owners may contact Kenworth customer service at 1-425-828-5888 and Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWG and 24PBG.
Owner notification: August 6, 2024 · Filing manufacturer: PACCAR Incorporated
NHTSA 25V436000
- Component
- EXTERIOR LIGHTING
- Report received
- June 26, 2025
- Potential units
- 56,260campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment.".
Why it matters: Delayed and unsteady headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash. In addition, an unexpected position change of the lift axles may increase the risk of injury.
Remedy
Dealers will update the VCU software, free of charge. Owner letters were mailed August 19, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's number for this recall is 25PACF.
Owner notification: August 19, 2025 · Filing manufacturer: PACCAR Incorporated
NHTSA 25V353000
- Component
- SERVICE BRAKES, AIR
- Report received
- May 28, 2025
- Potential units
- 315campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 2026 Peterbilt 548, 589, and 2024-2026 Peterbilt 567 trucks. The rear brake piping assembly may have insufficient clearance, which can result in a loss of service brakes or anti-lock brake function.
Why it matters: Brake failure can increase the risk of a crash.
Remedy
Dealers will install new brake hoses and correct the rear brake piping assembly, free of charge. Owner letters were mailed September 8, 2025. Owners may contact Peterbilt's customer service at 1-940-591-4220. PACCAR's number for this recall is 25PBE.
Owner notification: September 8, 2025 · Filing manufacturer: PACCAR Incorporated
NHTSA 25V041000
- Component
- ELECTRICAL SYSTEM, EXTERIOR LIGHTING
- Report received
- January 29, 2025
- Potential units
- 5,378campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth T180, Peterbilt 535, 567, 2025-2026 Kenworth T280, 2023-2026 Kenworth T380, 2024-2026 Kenworth T480, 2024-2026 Peterbilt 536, 537, and 548 trucks. The exterior lighting switch may fail, resulting in the hazard lights and the instrument display back-light brightness adjustment not functioning. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 108, "Lamps, Reflective Devices and Associated Equipment.".
Why it matters: Inoperative hazard lights cannot alert other drivers as intended. In addition, the inability to adjust the brightness on the instrument panel display can make it difficult to see critical safety information or distract the driver. Both scenarios can increase the risk of a crash.
Remedy
Dealers will update the vehicle cab controller unit (VECU) software, free of charge. Owners are advised that a non-responsive switch can be temporarily reset by a key cycle. Owner notification letters were mailed March 26, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 25KWB and 25PBB.
Owner notification: March 26, 2025 · Filing manufacturer: PACCAR Incorporated
NHTSA 24V915000
- Component
- ELECTRICAL SYSTEM, SERVICE BRAKES, HYDRAULIC
- Report received
- December 9, 2024
- Potential units
- 220,764campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.
Why it matters: Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.
Remedy
Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWL and 24PBL.
Owner notification: February 3, 2025 · Filing manufacturer: PACCAR Incorporated
NHTSA 24V908000
- Component
- STEERING
- Report received
- December 3, 2024
- Potential units
- 68campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2024 Peterbilt 367, 389, 548, Kenworth T480, T800, 2024-2025 Peterbilt 520, 567 and Kenworth T880 vehicles with PACCAR 20k steer axles. The steering arm and/or tie rod bracket fasteners may fail, resulting in a loss of steering control.
Why it matters: A loss of steering control increases the risk of a crash.
Remedy
Dealers will install new correctly torqued fasteners, free of charge. Owner notification letters were mailed January 21, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 or Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWK and 24PBK.
Owner notification: January 21, 2025 · Filing manufacturer: PACCAR Incorporated
NHTSA 24V789000
- Component
- FUEL SYSTEM, DIESEL
- Report received
- October 23, 2024
- Potential units
- 5,690campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth C500, T680, T800, T880, W900, W990, Peterbilt 567, 579, and 589 trucks, equipped with Cummins X15 diesel engines. The fuel pump barrels may fracture and cause a fuel leak, which can result in an engine stall.
Why it matters: An engine stall increases the risk of a crash.
Remedy
Dealers will replace the fuel pump barrels, free of charge. Owner notification letters were mailed November 15, 2024. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. Owners may also contact Cummins Customer Service at 812-377-5000. PACCAR's numbers for this recall are 24KWH and 24PBH.
Owner notification: November 15, 2024 · Filing manufacturer: PACCAR Incorporated
NHTSA 24V233000
- Component
- STEERING
- Report received
- March 27, 2024
- Potential units
- 782campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2025 Peterbilt 536, 548, 567, 579, and Kenworth T280, T380, T480, T680, T880, and W990 vehicles. The steering gear sector shaft may have been improperly heat-treated, which can cause the gear teeth to crack or fracture.
Why it matters: Fractured steering gear teeth can cause a loss of steering control, increasing the risk of a crash.
Remedy
Dealers will inspect the serial numbers, and replace the steering gears as necessary, free of charge. Owner notification letters were mailed August 7, 2024. Owners may contact Kenworth customer service at 1-425-828-5888 and Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24PBF and 24KWF.
Owner notification: July 29, 2024 · Filing manufacturer: PACCAR Incorporated
NHTSA 24V044000
- Component
- STEERING
- Report received
- January 25, 2024
- Potential units
- 45,887campaign-wide
Defect and consequence
Defect: PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.
Why it matters: A loss of steering control increases the risk of a crash.
Remedy
Dealers will inspect and replace the steering gears as necessary, free of charge. Owner notification letters were mailed March 20, 2024. Owners may contact Peterbilt customer service at 1-940-591-4220 and/or Kenworth customer service at 1-425-828-5888. PACCAR's numbers for this recall are 24PBC and 24KWC.
Owner notification: March 20, 2024 · Filing manufacturer: PACCAR Incorporated
02 / COMPONENT BREADTH