2017 Ic Bus Cesb recalls

Defect: International Motors, LLC (International) is recalling certain 2016-2024 IC Bus CESB school buses. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Why it matters: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a silicone black jumper harness, free of charge. Owner notification letters were mailed December 15, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25510. Vehicles previously repaired under 23V398 will need to have the new remedy completed.

Owner notification: December 15, 2025 · Filing manufacturer: International Motors, LLC

Defect: International Motors, LLC (International) is recalling certain 2016-2026 IC Bus CESB and 2016-2021 RESB school buses. The underfloor reinforcement may not have been installed, compromising the structural integrity of the buses. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 210, "Seat Belt Assembly Anchorages" and 222, "School Bus Passenger Seating and Crash Protection.".

Why it matters: Reduced structural integrity may increase the risk of injury in a crash.

Dealers will inspect and install a reinforcement channel as necessary, free of charge. Owner notification letters were mailed December 8, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25514.

Owner notification: December 8, 2025 · Filing manufacturer: International Motors, LLC

Defect: Navistar, Inc. (Navistar) is recalling certain 2017-2021 IC CE School Buses equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Why it matters: A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater non-operable and remove the fuse supplying electrical power to the fuel heater and install a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1-800-286-6467.

Owner notification: May 28, 2020 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2017 IC CE transit buses equipped with Bendix ADB 22X brake calipers. The driver side rear brakes may drag.

Why it matters: A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Navistar will notify owners, and dealers will replace the left rear caliper with a redesigned adjuster mechanism, free of charge. The recall began July 12, 2019. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 19507.

Owner notification: July 12, 2019 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2016-2020 IC CE and 2019 IC RE school buses equipped with Bendix ADB 22X brake calipers. The driver side rear brakes may drag.

Why it matters: A dragging brake may cause damage to the brake components, which may activate the ABS warning light. The warning light may cause the driver to immediately stop the vehicle and transfer occupants. Additionally, the high temperatures at the wheel end can increase the risk of a fire. Either condition increases the risk of injury.

Navistar will notify owners, and dealers will replace the left rear caliper with a redesigned adjuster mechanism, free of charge. The recall began July 12, 2019. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 19506.

Owner notification: July 12, 2019 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2017-2020 IC Bus CESB school buses equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electrical wiring within the fuel heater may overheat and may cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Why it matters: A fire increases the risk of injury. An engine stall can increase the risk of crash.

Cummins will notify the affected Navistar owners. Cummins dealers will replace the fuel heater with a newly designed fuel heater, free of charge. The recall began May 2, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Navistar customer service at 1-800-448-7825.

Owner notification: May 2, 2019 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2015-2019 IC Bus CE school buses, equipped with certain S-Series and K-Series Titanium Wheelchair Lifts, models K200, K201, K550, K551, S200, S2201, S550 and S551. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.

Why it matters: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.

Navistar will notify owners, and IC Bus or Ricon dealers will replace the injection molded cam with an aluminum machined cam, free of charge. The recall began October 5, 2018. Owners may contact Navistar customer service at 1-800-448-7825.

Owner notification: October 5, 2018 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2016-2019 IC bus CE school buses equipped with 8.8L liquid propane gas (LPG) engines. The LPDM relay for the propane booster pump and the scavenge pump may intermittently fail, causing the fuel pump to stop.

Why it matters: If the fuel pump stops, the bus will stall, increasing the risk of a crash.

Navistar will notify owners, and dealers will replace the LPDM relay, free of charge. The recall began on April 12, 2018. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 18501.

Owner notification: April 12, 2018 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2017 IC Bus CE and 2016-2017 IC Bus RE school buses, equipped with certain IMMI school bus seat assemblies equipped with 3-point lap and shoulder belts. Under load, the seat belt buckle mount rod can fracture. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages.".

Why it matters: In the event of a crash, if the buckle mount rod fractures, the seat occupant may not be restrained, increasing their risk of injury.

Navistar will notify owners, and dealers will replace the 3-point seat belt rods, free of charge. The recall began on December 14, 2017. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 17512.

Owner notification: December 14, 2017 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2016-2018 IC Bus CE school buses equipped with a plastic booster pump, 17k Webasto heater and a Webasto Smart Temp timer. The power circuit for the heater booster pump may be unfused.

Why it matters: Without circuit protection, if the vehicle has a heater booster pump electrical failure, it can increase the risk of a fire.

Navistar will notify owners, and dealers will relocate the circuit to a fused section of the power distribution center, free of charge. The recall began on May 12, 2017. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 17503.

Owner notification: May 12, 2017 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain model year 2015 IC Bus AE and BE, 2015-2017 CE and 2016-2017 RE school buses, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Why it matters: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Navistar will notify owners, and dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 28, 2016. Owners may contact Navistar customer service at 1-331-332-1590, or Ricon Customer Service at 1-800-322-2884.

Owner notification: December 28, 2016 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2016-2017 IC Bus CE school buses manufactured June 15, 2015, to May 20, 2016, and RE school buses manufactured June 18, 2015, to April 27, 2016. These buses may have been manufactured without reflective outline tape around the emergency exit roof hatches. As a result, these vehicles fail to comply with the requirements for Federal Motor Vehicle Safety Standard (FMVSS) number 217, "Bus Emergency Exits and Window Retention and Release.".

Why it matters: Absence of the reflective outline tape may reduce conspicuity of the emergency exit roof hatches, reducing the ability of emergency personnel to identify and gain access to the emergency roof hatches, possibly increasing the passenger's risk of personal injury or death during an emergency.

Navistar will notify owners, and dealers will install reflective tape around the roof hatch, free of charge. The recall began n July 18, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 16505.

Owner notification: July 18, 2016 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. is recalling certain model year 2016-2017 IC CE school buses manufactured from November 24, 2014, through January 22, 2016. In the affected vehicles, the hood straps used to latch the hood closed may become elongated and not return to their original length. As a result, the hood may open unexpectedly when the bus is braking.

Why it matters: If the hood opens while braking, the driver's vision may be obstructed, increasing the risk of a crash.

Navistar will notify owners, and dealers will replace the hood straps, free of charge. The recall began on April 18, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 16502.

Owner notification: April 18, 2016 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain model year 2016-2017 IC CE school buses manufactured May 4, 2015, to December 15, 2015, and 2016 IC RE school buses manufactured July 17, 2015, to December 15, 2015, and equipped with certain Transpec T6000, T6100, and T7000 series school bus stop arms. The affected stop arms have a reflective decal that may peel loose from the stop arm. As such, these stop arms fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 131, "School Bus Pedestrian Safety Devices.".

Why it matters: Without a reflective decal, the stop arms would have reduced visibility to other drivers, increasing the risk of a crash.

Navistar will notify owners, and dealers will replace the stop arm blade assembly, free of charge. The recall began on March 17, 2016. Owners may contact Navistar customer service at 1-331-332-1590, or Specialty customer service at 1-800-951-7867. Navistar's number for this recall is 16501.

Owner notification: March 17, 2016 · Filing manufacturer: Navistar, Inc.