2021 Ic Bus Ce recalls

Defect: Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Why it matters: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23517.

Owner notification: September 29, 2023 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2021-2024 International HV, HX, LoneStar, LT, MV, eMV, and RH trucks, and IC Bus CE, 2021-2023 IC Bus RE, and 2022-2023 IC Bus TC Commercial Buses. The anti-lock brake system (ABS) indicator light does not remain illuminated when a malfunction exists, and when the vehicle's ignition switch is on, and the vehicle is in motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems.".

Why it matters: An ABS indicator light that fails to remain illuminated will not alert the driver of an ABS malfunction, which could increase the risk of a crash.

Towing variant vehicles under this campaign will not be repaired under recall 24V-8918. Dealers will update the software, free of charge. Owner notification letters are expected to be mailed July 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23515.

Owner notification: July 18, 2023 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2020-2021 IC CE transit buses. The engine control module (ECM) may set a fault code that results in an unexpected engine shut down.

Why it matters: Unexpected engine shut down can increase the risk of a crash. Additionally, a disabled school bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

Dealers will update the engine control unit software, free of charge. Owner notification letters notifying owners of the safety risk were mailed January 18, 2022. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 21508.

Owner notification: January 18, 2022 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2021-2022 IC Bus CE school buses. The weather seal of the illuminated stop sign unit may allow contaminants to enter into the unit, resulting in reduced performance. In certain cases, an electrical short may occur which would render the unit inoperable.

Why it matters: If the sign performance is inhibited, or completely inoperable, it can reduce the visibility for oncoming drivers, increasing the risk of a crash.

Navistar will notify owners, and dealers will replace the LED illuminated school bus signs, free of charge. The recall began December 15, 2020. Owners may contact Navistar customer service at 1-800-448-7825.

Owner notification: December 15, 2020 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2017-2021 IC CE School Buses equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Why it matters: A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater non-operable and remove the fuse supplying electrical power to the fuel heater and install a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1-800-286-6467.

Owner notification: May 28, 2020 · Filing manufacturer: Navistar, Inc.

Defect: Navistar, Inc. (Navistar) is recalling certain 2017-2020 International WorkStar and International DuraStar, 2018-2019 IC 1300 FBC Commercial and IC HC Commercial, 2018-2021 IC CE Commercial, International MV and International HV, and 2019-2021 IC TC Commercial buses with Cummins B6.7 diesel engines with a fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

Why it matters: A fire increases the risk of injury. An engine stall can increase the risk of a crash.

Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater inoperable and removing the fuse supplying electrical power to the fuel heater and installing a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1-800-286-6467.

Owner notification: May 28, 2020 · Filing manufacturer: Navistar, Inc.