2020 Nova Bus Lfs Artic recalls

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.

Why it matters: Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.

Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342.

Owner notification: November 16, 2022 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 1997-2002, 2005-2024 LFS, 2009-2014, and 2016 - 2024 LFS Artic transit buses. The low brake air pressure warning light may fail to illuminate when the engine is off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems.".

Why it matters: A low brake air pressure warning light that fails to illuminate when the engine is off will not alert the driver to a low brake pressure condition, increasing the risk of a crash if the parking brake is disengaged before starting the engine.

Nova Bus will update the firmware, free of charge. Interim owner notification letters explaining the safety risk were mailed by July 17, 2026. Owners will receive another notice once remedy becomes available. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5918. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 2, 2026.

Owner notification: Date not reported · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2020 LFS Artic and 2019-2023 LFS transit buses. The driver's speaker hole door may have been built with the prime glazing manufacturer DOT code mark missing. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials.".

Why it matters: A missing DOT code mark may result in the door being replaced with the incorrect type of plastic, reducing visibility and increasing the risk of a crash.

Nova Bus will replace the plastic panel door, free of charge. Interim owner notification letters explaining the safety risk were mailed by July 7, 2026. Owners will receive another notice once remedy becomes available. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5884. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 23, 2026.

Owner notification: Date not reported · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2016-2018, 2020, 2022-2023 LFS and 2019-2020 LFS Artic transit buses. The driver's seat belt tension-reliving device may fail to disengage without manual intervention. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection.".

Why it matters: Failure of the tension-reliving device may prevent the seat belt from properly restraining the driver, increasing the risk of injury during a crash.

Nova Bus will remove the seat belt tension-reliving device, free of charge. Owner notification letters were mailed May 22, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Nova Bus' number for this recall is CR5873. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 23, 2026.

Owner notification: May 22, 2026 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2013-2019 LFS and 2019-2020 LFS Artic transit buses equipped with Double Transversal seats. The passenger seat mounting rails may crack, causing the seat to detach and fall to the floor.

Why it matters: A seat that falls unexpectedly increases the risk of injury to passengers in or near to the seat.

Nova Bus will replace the attachment brackets, free of charge. Interim owner notification letters explaining the safety risk were mailed by April 10, 2026. Owners will receive another notice once remedy becomes available. Owners may contact Nova Bus customer service at 1-450-472-6410. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 4, 2026.

Owner notification: Date not reported · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies.".

Why it matters: A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.

Nova Bus will install additional seat stoppers to the driver's rear partition, free of charge. Owner notification letters are expected to be mailed July 4, 2025. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously recalled under 23V-350 will need to have the new remedy completed.

Owner notification: July 4, 2025 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.

Why it matters: An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.

Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637.

Owner notification: January 28, 2025 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2023 LFS and 2019-2020 LFS Arctic buses. The glazing used on the glass windows may reduce the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials.".

Why it matters: Reduced visibility while driving can increase the risk of a crash.

Nova Bus will inspect the vehicles and replace the driver shield glazing as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5626.

Owner notification: October 10, 2024 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2020-2023 LFS and LFS Artic transit buses. The brackets retaining the Mobile Climate Control HVAC Unit could fail and allow the unit to detach from the bus.

Why it matters: An HVAC unit that detaches from a bus can create a road hazard, increasing the risk of a crash.

Nova Bus will inspect the existing brackets and install additional brackets, as necessary, free of charge. Owner notification letters were mailed December 20, 2023. Owners may contact Nova Bus customer service at 1-800-350-6882. Nova Bus's number for this recall is CR5508.

Owner notification: December 20, 2023 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova) is recalling certain 2017-2023 LFS and 2017-2022 LFS Artic transit buses. The 24-volt power cable and grounded mounting fastener that secures the fuse holder may short circuit.

Why it matters: An electrical short circuit can overheat the fuse holder and increase the risk of a fire while driving or parked.

Nova will insect, remove, and clean the fuse holder and cable lugs as necessary, free of charge. Owner letters were mailed November 7, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5445. This recall replaces and expands recall number 22V-416. Vehicles previously repaired under recall 22V-416 will need to have the new remedy completed.

Owner notification: November 7, 2023 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova) is recalling certain 2019-2023 LFS and LFS Artic transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.

Why it matters: A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

Dealers will inspect the output yoke bolts, and if necessary, tighten loose output yoke bolts, free of charge. Phase 1 will include 2019-2023 LFS vehicles. Nova notified dealers on 10/03/2024 and notified Phase 1 owners on 10/27/2024. Phase 2 will include 2019-2020 LFS Artic vehicles. Interim letters informing owners of the safety risk were mailed on October 27, 2023. A second notice will be mailed to Phase 2 owners once the remedy is available, expected in January 2025. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5442.

Owner notification: October 27, 2023 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019-2022 LFS Artic buses. The radiator fan's electrical fuse holder may experience excessive corrosion which can result in an electrical short.

Why it matters: An electrical short increases the risk of a fire.

Nova Bus will provide the remedy parts and service document instructions, free of charge. Owner notification letters were mailed on June 29, 2022. Owners may contact Nova Bus' customer service at 1-800-350-6682. Nova Bus' number for this recall is CR5259.

Owner notification: June 29, 2022 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment.".

Why it matters: The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69.

Owner notification: June 27, 2022 · Filing manufacturer: Nova Bus (US) Inc.

Defect: Nova Bus is recalling certain 2016-2020 LFS and LFS Artic vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Why it matters: A fuel leak in the presence of an ignition source increases the risk of a fire.

Dealers will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on July 9, 2021. Owners may contact Nova Bus customer service at 1-800-350-6682.

Owner notification: July 9, 2021 · Filing manufacturer: Nova Bus

Defect: Nova Bus (Nova) is recalling certain 2020 Nova Bus LFS transit buses. Certain power steering pipes from the rear engine bay to the front gear box may separate at the connection joint. This may cause a power steering assist lost and power steering fluid may leak from the ceiling into the passenger compartment.

Why it matters: A loss of power steering assist may increase the risk of a crash. A power steering fluid leak into the passenger cabin may increase the risk of a passenger injury.

Nova Bus will notify owners, provide instructions for inspecting and replacing the power steering pipes, free of charge. The recall began October 7, 2020. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR4963.

Owner notification: October 7, 2020 · Filing manufacturer: Nova Bus