2015 Spartan K2 recalls

Defect: Spartan Motors USA (Spartan) is recalling certain 2011-2017 Gladiator, 2016-2017 MetroStar, 2012-2018 K2, 2011-2018 K3, 2017-2018 K4, and 2011-2017 MM vehicles. The ball joints on the independent front suspension (IFS) modules can loosen and separate, leading to a partial loss of steering.

Why it matters: A separated ball joint can cause a loss of steering control, increasing the risk of a crash.

Spartan will notify owners, and dealers will remove, clean, apply thread locker, and reinstall the properly torqued ball joint, free of charge. The recall began on March 24, 2017. Owners may contact Spartan customer service at 1-800-543-4277. Spartan's number for this recall is 17004.

Owner notification: March 24, 2017 · Filing manufacturer: Spartan Motors USA

Defect: Spartan Motors USA (Spartan) is recalling certain model year 2015-2016 K2, and K3 vehicles manufactured November 19, 2013, to May 7, 2015. Power could be lost in the vehicle's air suspension system.

Why it matters: A failure of the air suspension system could result in a loss of some vehicle control, increasing the risk of a crash.

Spartan will notify owners, and dealers will install a independent electrical circuit that will supply power to the control module, free of charge. The recall began on September 9, 2015. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 15018.

Owner notification: September 9, 2015 · Filing manufacturer: Spartan Motors USA

Defect: Spartan Motors, Inc. (Spartan) is recalling certain model year 2015-2016 K2, K3 and MM chassis manufactured October 2, 2013, to April 2, 2015. In the affected vehicles, the fasteners that attach the stay rod (v-rod) to the rear drive axle may not have been installed with thread locker or tightened in the correct sequence.

Why it matters: If the fasteners come loose, the stay rod may disconnect from the rear axle, resulting in a loss of control, increasing the risk of a crash.

Spartan will notify owners, and dealers will replace the fasteners using thread lock, tightening them in the proper sequence and with the required torque values, free of charge. The recall began on August 11, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15010.

Owner notification: August 11, 2015 · Filing manufacturer: Spartan Motors, Inc.

Defect: Spartan Motors, Inc. (Spartan) is recalling certain model year 2013-2015 Gladiator, K2, K3, MetroStar, and MM motorhome and emergency response chassis cabs manufactured November 28, 2012, to October 15, 2013. The castle nuts for the steering linkage may loosen, allowing the steering linkage to separate.

Why it matters: If the steering linkage separates, a loss of steering control would occur, increasing the risk of a crash.

Spartan will notify owners, and dealers will inspect and tighten the castle nuts, as necessary, free of charge. The recall began on January 26, 2015. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 14023.

Owner notification: January 26, 2015 · Filing manufacturer: Spartan Motors, Inc.

Defect: Spartan Motors, Inc. (Spartan) is recalling certain model year 2013-2015 Gladiator, DR, K2, K3, MetroStar, MM, and NVS vehicles manufactured December 14, 2011, to October 21, 2014, equipped with certain Wabco Quick Release Valves with Double Check. In the affected valves, the rubber diaphragm may be damaged by sharp edges on the valve seat ribs, reducing the available air pressure in the air tanks.

Why it matters: The reduced air pressure levels may reduce braking performance and/or the parking brakes could reapply, increasing the risk of a crash.

Spartan will notify owners, and dealers will inspect and replace the valve, free of charge. The recall began January 22, 2015. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 14021.

Owner notification: January 22, 2015 · Filing manufacturer: Spartan Motors, Inc.