2011 Toyota Tundra recalls

Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

Why it matters: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

Owner notification: January 21, 2022 · Filing manufacturer: Toyota Motor Engineering & Manufacturing

Defect: Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Why it matters: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

Owner notification: November 25, 2015 · Filing manufacturer: Toyota Motor Engineering & Manufacturing

Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Why it matters: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Owner notification: January 29, 2015 · Filing manufacturer: Southeast Toyota Distributors, LLC

Defect: Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims.".

Why it matters: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Owner notification: May 28, 2013 · Filing manufacturer: Southeast Toyota Distributors, LLC

Defect: Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Why it matters: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Owner notification: March 21, 2013 · Filing manufacturer: Southeast Toyota Distributors, LLC

Defect: Gulf states toyota is recalling certain model year 2011 tundra vehicles that have an inaccurate load carrying capacity label. these vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 110, â“tire selection and rims.â”.

Why it matters: An inaccurate label could lead to vehicle overloading which could result in tire failure, increasing the risk of a crash.

Gulf states toyota will notify owners and will provide a corrected label free of charge. the customer will have the option for dealers to install the label free of charge. the safety recall began on may 24, 2012. owners may contact gulf state toyota at 1-800-444-1074.

Owner notification: May 24, 2012 · Filing manufacturer: GULF STATES TOYOTA, INC.

Defect: Southeast toyota is recalling certain model year 2007-2011 tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring systems." the tpms on some vehicles may not have been properly calibrated and as a result the low tire pressure warning lamp may not illuminate should the inflation pressure in one or more of the vehicle's tires fall below the threshold for when the low tire pressure warning lamp should illuminate.

Why it matters: Drivers will not receive a warning from the tire pressure monitor that one or more tires are underinflated, increasing the risk that the vehicle will be driven with one or more underinflated tires, increasing the risk of a tire failure that may lead to a crash.

Dealers will recalibrate the tire pressure monitoring system in accordance with the regulation free of charge. the safety recall began during july 2011. owners may contact southeast toyota customer assistance center toll free at 1-800-301-6859, monday through friday, 8:30 am to 5:00 pm, eastern standard time.

Owner notification: July 11, 2011 · Filing manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS, LLC

Defect: Toyota is recalling certain model year 2011 tundra vehicles equipped with a 3-joint type propeller shaft. due to improper casting of the slip yokes, there is a possibility that the slip yoke may break, causing the propeller shaft to separate at the joint and come into contact with the road surface.

Why it matters: The driver could experience loss of motive power and vehicle control, increasing the risk of a crash.

Toyota will notify owners and inspect the propeller shaft and, if necessary, replace it free of charge. the safety recall is expected to begin during may 2011. owners may contact toyota at 1-800-331-4331.

Owner notification: May 13, 2011 · Filing manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

Defect: Gulf states toyota is recalling certain model year 2011 fj cruiser and model year 2009-2011 tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring systems." the tpms on some vehicles may not have been properly calibrated and as a result the low tire pressure warning lamp may not illuminate should the inflation pressure in one or more of the vehicle's tires fall below the threshold for when the low tire pressure warning lamp should illuminate.

Why it matters: Drivers will not receive a warning from the tire pressuring monitor that one or more tires are underinflated increasing the risk that a vehicle will be driven with one or more underinflated tires and increasing the risk of a tire failure that may lead to a crash.

Dealers will recalibrate the tire pressure monitoring system in accordance with the regulation free of charge. the safety recall is expected to begin during june 2011. owners may contact gulf state toyota customer assistance center toll free at 1-800-444-1074 monday through thursday, 8:30 am to 5:00 pm, or friday 8:30 am to 4:00 pm central standard time.

Owner notification: July 19, 2011 · Filing manufacturer: GULF STATES TOYOTA, INC.

Defect: Toyota is recalling certain model year 2008 through 2011 fj cruiser, land cruiser, tacoma, sequoia and tundra vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 138, "tire pressure monitoring system (tpms)." when factory-installed wheels and tires were replaced with toyota authorized accessory wheels and lt tires prior to first sale, the tire pressure monitoring systems were not re-calibrated correctly and therefore do not start illuminating the low tire pressure warning telltale at the required minimum activation pressure.

Why it matters: Failure to warn of tire deflations is a non-compliance with fmvss 138 and could lead to tire failure increasing the risk of a crash.

For the land cruiser, sequoia, tacoma and tundra vehicles, the dealer will re-calibrate the tire pressure monitoring system on affected vehicles and install an updated tire and loading information label at no charge. for the fj cruiser vehicles, the tpms cannot be reset so the electronic control unit (ecu) for the tpms will be replaced. toyota is currently developing the remedy ecu. if an owner is not certain whether his or her vehicle is equipped with these accessories, please contact any toyota dealer for an inspection at no charge. the safety recall began on march 31, 2011. owners may contact toyota at 1-800-331-4331.

Owner notification: March 31, 2011 · Filing manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.