2008 Orion V recalls

Defect: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.

Why it matters: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.

DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.

Owner notification: November 29, 2013 · Filing manufacturer: Daimler Buses North America

Defect: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.

Why it matters: Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.

DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1-800-882-8054.

Owner notification: September 28, 2012 · Filing manufacturer: DAIMLER BUSES NORTH AMERICA, INC.

Defect: Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. the morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, "throttle"; "off" or "front" and "on" or "rear" selecting the active engine control station. if a person operating the engine from the "rear" position (at the engine) fails to place the switch in the "off" or "front" position and the engine rpm was set to above idle during maintenance for example, when the bus is started from the driver's station the engine could change to the higher rpm resulting in unwanted engine power.

Why it matters: The bus could accelerate at a higher rate than anticipated increasing the risk of a crash.

Daimler will provide instructions to modify the wiring to the morse throttle control switch. this service will be performed free of charge. the safety recall began on april 1, 2010. owners may contact daimler buses at 1-800-716-7466.

Owner notification: April 1, 2010 · Filing manufacturer: DAIMLER BUSES NORTH AMERICA, INC.