2006 Glaval Apollo recalls

Defect: Glaval is recalling certain model year 2006 through 2007 transit buses built on ford, gmc, chevrolet, and freightliner chassis and equipped with carrier genv em-1 evaporator units. due to time, temperature, and/or vibration, the fuse may loosen in the fuse holder resulting in high resistance and arcing.

Why it matters: If sufficient arcing occurs, the fuse holder may melt, and a vehicle fire may occur.

Glaval will notify owners and provide information on how to obtain the retrofit kit from carrier along with repair instructions. this service will be performed free of charge. the safety recall began on january 14, 2012. (see carrier's recall campaign 11e-003.) owners may contact carrier at 1-800-348-7440.

Owner notification: January 14, 2012 · Filing manufacturer: GLAVAL BUS DIVISION

Defect: Glaval is recalling certain model year 2002, 2003, 2006, 2007, and 2008 ford e350/e450 universal, chevy/gmc 4500/5500 titan and freightliner mb-55 apollo transit buses manufactured from august 1999 through july 2007, and equipped with a trans/air ta73 evaporator. the evaporator utilizes a power resistor to regulate blower speed. should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.

Why it matters: This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. the overheating can result in a fire.

Glaval in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. this service will be performed free of charge. the safety recall began on december 23, 2010. owners may contact trans air warranty and service center at 1-800-673-2446.

Owner notification: December 23, 2010 · Filing manufacturer: GLAVAL BUS DIVISION

Defect: Glaval bus is recalling certain model year 2006 through 2010 universal, titan, titan ii, primetime, sport, and apollo transit buses manufactured between december 2007 and december 2009 fitted with ricon public use lifts. the restraint belt on these lifts was designed to prevent the lift from moving, unless the tongue of the belt is fully engaged and latched in the buckle. ricon has discovered, however, that it is possible for the operator to insert the belt tongue into the buckle without fully engaging the latching mechanism. in this case, the restraint belt would appear to be latched, and the operator could run the lift. if the restraint belt tongue is not fully engaged into the restraint belt buckle, and latched, the lift may operate with an occupant on the platform.

Why it matters: The user of the lift could be injured should the lift move without the restraint belt properly buckled.

Glaval bus is working with ricon and ricon will be performing the remedy for this campaign. please see ricon's defect report 09e-060. ricon will provide customers with a warning decal and a dvd-based training aid. the safety recall began on april 26, 2010. owners may contact ricon at 1-818-267-3000 or glaval bus at 1-800-322-2884.

Owner notification: April 26, 2010 · Filing manufacturer: GLAVAL BUS DIVISION