2004 Toyota Sienna recalls

Defect: Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2004-2011 Sienna vehicles originally sold in, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin and the District of Columbia. The affected vehicles have a spare tire carrier assembly mounted under the vehicle whose attachment cable may corrode due to high concentrations of road salt splashing onto the spare tire carrier.

Why it matters: If the carrier cable is corroded due to road salt, the spare tire may separate from the vehicle, increasing the risk of a crash.

Toyota sent owners in August 2014 an interim notification to advise owners of the recall and that dealers will perform an interim remedy to remove the spare tire and relocate it to the luggage compartment, free of charge. Owners are being mailed a second letter as parts become available and dealers will replace the spare tire carrier assembly with an improved one, free of charge. The remedy campaign is being performed in phases. The first phase of the recall began July 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331. NOTE: 2004-2010 Siennas subject to this recall were subject to recall campaign 10V-160 initiated in 2010. Those owners are advised that they must have their vehicles remedied again under this campaign and that having the earlier recall completed did not remedy their vehicles. Additionally, model year 1998-2003 Siennas were recalled as part of safety recall 10V-160. Owners of those vehicles that have not had not the remedy performed on their vehicles, should contact their Toyota dealer to schedule a free repair.

Owner notification: July 7, 2015 · Filing manufacturer: Toyota Motor Engineering & Manufacturing

Defect: Toyota is recalling certain model year 2004-2005 Sienna vehicles manufactured January 10, 2003, through August 10, 2005; and model year 2007-2009 Sienna vehicles manufactured February 20, 2007, through December 12, 2008. In the affected vehicles, due to a problem within the shift lock solenoid, there is a possibility that the shift lever could be moved out of Park position without depressing the brake pedal.

Why it matters: If the shift lever is moved out of the Park position without the brake applied, the transmission will either engage a drive gear or Neutral, increasing the risk of a backover or roll away crash.

Toyota will mail interim notifications to owners beginning in late October 2013. When parts are available, owners will be sent a second notice and dealers will replace the shift lock solenoid, free of charge. Owners may contact Toyota at 1-800-331-4331.

Owner notification: February 27, 2014 · Filing manufacturer: Toyota Motor Engineering & Manufacturing

Defect: Toyota is recalling certain model year 2004 avalon vehicles; 2004 and 2005 camry, camry solara, highlander, and sienna vehicles, 2006 highlander hybrid; 2004 and 2005 lexus es330 and rx330; and 2006 lexus rx400h vehicles manufactured from june 1, 2004 through march 31, 2005, equipped with the 1mz-fe or 3mz-fe engine. the amount of adhesive agent applied between the outer ring and the torsional rubber damper (inner ring) in the crankshaft pulley may be inadequate. if the adhesive is insufficient, there is a possibility that the outer ring may become misaligned and it may not properly rotate with the inner ring, causing noise and/or illumination of the battery discharge indicator light.

Why it matters: In some cases, the belt for the power steering pump may become detached from the pulley which could result in a loss of power steering and a sudden increase in steering effort, increasing the risk of a crash.

Toyota will notify owners, and dealers will check the crankshaft pulley to identify whether it was produced by the u.s. supplier. if so, the dealer will replace the pulley with a new one at no charge. the safety recall is expected to begin during early january 2012. owners may contact toyota at 1-800-331-4331.

Owner notification: December 31, 2011 · Filing manufacturer: Toyota Motor Engineering & Manufacturing

Defect: Toyota is recalling certain model year 1998 through 2010 sienna passenger vehicles manufactured between august 7, 1997 and january 4, 2010, currently registered in or originally sold in connecticut, delaware, illinois, indiana, kentucky, maine, maryland, massachusetts, michigan, minnesota, new hampshire, new jersey, new york, ohio, pennsylvania, rhode island, vermont, washington district of columbia, virginia, west virginia, and wisconsin. the subject vehicles are equipped with the spare tire stowed under the vehicle. if the vehicle is operated in the cold climate regions of the united states where road salt is frequently used, water splashed backwards with high concentrations of road salt can reach the spare tire carrier and corrode the spare tire carrier assembly cable.

Why it matters: The cable may break due to excessive corrosion and the spare tire may separate from the vehicle, possibly resulting in a vehicle crash.

Toyota will notify owners with an interim letter initially instructing them to bring their vehicle to authorized dealers to inspect for corrosion. a second notice will be sent when the permanent remedy is available. for more information, please see toyota's amended recall report of july 19, 2010. the safety recall is expected to begin on october 12, 2010. owners may contact toyota at 1-800-331-4331.

Owner notification: October 12, 2010 · Filing manufacturer: TOYOTA MOTOR NORTH AMERICA, INC.

Defect: Southeast toyota is recalling certain model year 2005-2011 passenger vehicles for failing to comply with the requirements of federal motor vehicle safety standard no. 110, "tire selection and rims." these vehicles were sold without the requisite load carrying capacity modification labels.

Why it matters: A driver may overload a vehicle which may increase the risk of a crash.

Dealers will mail to consumers the corrected label or the customer will have the option for dealers to install the label free of charge. the safety recall began on may 27, 2010. owners may contact southeast toyota at 1-800-301-6859.

Owner notification: May 27, 2010 · Filing manufacturer: SOUTHEAST TOYOTA DISTRIBUTORS, LLC